Product ID:CIRCUIT WORKS CONDUCTIVE PEN, CW2200-STP
MSDS Date:01/06/1999
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CJHLW

Emergency Phone: 414-273-3850

Cage: 21267

Telephone: 770-424-4888/800-645-5244

Cage: 21267

2-PROPANOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

LD50 LC50 Mixture:LD50: (ORAL,RAT) >5 GM/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MAY BE HARMFUL BY INHALATION,
INGESTION, OR SKIN ABSORPTION. CAUSES SEVERE EYE IRRITATION. CAUSE
SKIN IRRITATION. MATERIAL IS IRRITATING TO MUCOUS MEMBRANES AND
UPPER RESPIRATORY TRACT. CAN CAU SE CNS DEPRESSION. PROLONGED
EXPOSURE CAN CAUSE: NAUSEA, HEADACHE AND VOMITING, NARCOTIC EFFECT.
PROLONGED OR REPEATED EXPOSURE TO SKIN CAUSES DEFATTING AND
DERMATITIS. CHRONIC: TARGET ORGANS(S): NERV ES, KIDNEYS, LIVER. TO
THE BEST OF OUR KNOWLEDGE, THE CHEMICAL, PHYSICAL, AND
TOXICOLOGICAL PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:EYES: IMMEDIATELY FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. ASSURE ADEQUATE FLUSHING OF EYES BY SEPARATING
THE EYELIDS WITH FINGERS. SKIN: IMMEDIATELY WASH WITH SOAP AND
COPIOUS AMO UNTS OF WATER. INHAL: REMOVE TO FRESH AIR. IF NOT
BREATHING GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT,
GIVE OXYGEN. INGESTION: WASH OUT MOUTH WITH WATER PROVIDED PERSON
IS CONSCIOUS. CALL A PHYSICIAN. REMOVE AND WASH CONTAMINATED
CLOTHING PROMPTLY.

Flash Point:=11.7C, 53.F
53F,11C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL POWDER OR APPROPRIATE
FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS.
FLAMMABLE SOLID.
Unusual Fire/Explosion Hazard:VAPOR MAY TRAVEL CONSIDERABLE DISTANCE TO
SOURCE OF IGNITION AND FLASH BACK. CONTAINER EXPLOSION MAY OCCUR
UNDER FIRE CONDITIONS. WARNING: THIS MATERIAL IS CLASSIFIED AS AN
EXPLOSIVE WHEN DRY. FIRE FI GHTING SHOULD BE DONE FROM A REMOTE
POSITION.

Spill Release Procedures:SHUT OFF ALL SOURCES OF IGNITION. EVACUATE
AREA. WEAR NIOSH APPRVD SCBA, RUBBER BOOTS & HEAVY RUBBER GLOVES.
ABSORB ON SAND/VERMICULITE & PLACE IN CLOSED CONTAINERS FOR
DISPOSAL. USE NONSPARKING TOOLS . VENTILATE AREA AND WASH SPILL
SITE AFTER MATERIAL PICKUP IS COMPLETE.

Handling and Storage Precautions:ADDNL INFO: WARING: DANGEROUS WHEN
DRY. 2-PROPANOL CONTENT MUST BE MAINTAINED >25 WT. % FOR STORAGE.
MATL CNTNG <25% ALCOHOL IS AN EXPLOSIVE. CHECK 2-PROPANOL CONTENT
PERIODICALLY & ADD MORE ALCOHOL A S NEC. FLAMM (USA). HIGHLY FLAMM
(EU). IRRITANT.
Other Precautions:IRRITATING TO EYES, RESP SYS & SKIN. RISK OF SERIOUS
DMG TO EYES. TARGET ORGAN(S): NERVES, KIDNEYS. KEEP AWAY FROM
SOURCES OF IGNIT - NO SMOKING. IN CASE OF CONT W/EYES, RINSE IMMED
WITH PLENTY OF WAT ER & SEEK MED ADVICE. WEAR SUITABLE PROTECTIVE
CLOTHING. KEEP WET WITH: 2-PROPANOL. (SUPDAT)

Respiratory Protection:NIOSH APPROVED RESPIRATOR.
Ventilation:MECHANICAL EXHAUST REQUIRED.
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
MFR TRADE NAME/PART NO: 5-6 SEC (WITH 30% IPA). OTHER PREC: DO NOT GET
IN EYES, ON SKIN, ON CLOTHING. DO NOT BREATHE VAPOR. SEVERE EYE
IRRITANT. KEEP TIGHTLY CLOSED. KEEP AWAY FROM HEAT, SPARKS, AND O
PEN FLAME. DO NOT ALLOW MATERIAL TO BECOME DRY. STORE IN A COOL DRY
PLACE.

Boiling Pt:=83.C, 181.4F
Spec Gravity:1.230

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS, ACIDS, BASES, ACID ANHYDRIDES, HALOGENS, ALUMINUM.
Stability Condition to Avoid:DO NOT HEAT OVER: 60 DEGREES C.
Hazardous Decomposition Products:TOXIC FUMES OF: CARBON MONOXIDE,
CARBON DIOXIDE, NITROGEN OXIDES.

Waste Disposal Methods:BURN IN A CHEMICAL INCINERATOR EQUIPPED WITH AN
AFTERBURNER AND SCRUBBER BUT EXERT EXTRA CARE IN IGNITING AS THIS
MATERIAL IS HIGHLY FLAMMABLE. OBSERVE ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGUL ATIONS.

Toxicological Information:ACUTE EFTS: MAY BE HARMFUL BY INHAL,
INGEST/SKIN ABSORP. CAUSES SEV EYE IRRIT. CAUSES SKIN IRRIT. MATL
IS IRRIT TO MUC MEMB & UPPER RESP TRACT. CAN CAUSE CNS DEPRESS.
PRLNGED EXPOS CAN CAUSE: NAUS, HD CH & VOMIT, NARCOTI EFT.
PRLNGD/RPTD EXPOS TO SKIN CAUSES DEFAT & DERM. CHRONIC: TARGET
ORGAN(S): NERVES, KDINEYS, LIVER. TOX DATAL ORAL-RAT LD50:>5 GM/KG.
ORL-MUS LD50:>5 GM/KG. TXAPA9 33,159,1975. T XAPA9 33,159,1975.
ONLY SELECTED REGISTRY OF TOXIC EFTS OF CHEM SUBSTANCES (RTECS)
DATA IS PRESENTED HERE. SEE ACTUAL ENTRY IN RTECS FOR COMPLETE
INFORMATION.

Ecological:DATA NOT YET AVAILABLE.

Transport Information:CONTACT ALDRICH CHEMICAL COMPANY FOR
TRANSPORTATION INFORMATION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.